1989 BMW R100GS - Maintenance for Long Life?

Simondo

Registered user
Joined
Jul 29, 2010
Messages
28
Reaction score
0
Location
Pezenas, France
What do I need to do to extend the life of my (once) trusty GS? Can anyone recommend a list of mods?
I was preparing the bike for a 3000kms round trip to Siena, Tuscany, returning through Corsica. A week before I set off, it refused to start. We think it may be the transmission neutral switch.
Fearing further dramas on the road, I hired a Moto Guzzi V85tt. It worked well - a great round trip - without drama.
Time to buy a new bike? Maybe. But first, I decided: I want to inject some cash into my GS and get it properly looked over and parts replaced before they fail. I live in France so will be looking for a workshop/individual down here.
 
Neutral switch is an easy fix.
Can be done with the engine in situ. Remove the silencer, remove collector box (or Y piece)
Prop up rear of engine with a car jack. Remove rear engine mount through bolt. This will leave a hollow tube which can be levered down with a long screwdriver or tyre lever.
This gives access to the neutral switch. Undo the two wire, replace switch ( use a new crush washer)
Replace wires to neutral switch.
Meanwhile, stitch the cross tube in the freezer to cool and shrink it a little.
When cold, refit cross tube ( easier when it’s cold as it’s slightly smaller then)
Replace engine mount through bolt.
Replace collector box and silencer. Remove car jack from under engine ( not strictly necessary I believe, but I would always do it for peace of mind)

Sit back with a cold beer and congratulate yourself on a job well done
( until you discover that it was something else that caused the lack of starting!)

Ride safe y’all.
 
If it's the neutral switch it should start if you pull the clutch in.

A new wiring loom might be a good investment (BMW still sell them) but ignition switches tend to wear out and the relays (lights and starter relays) tend to fail after 30-40 years. Shoddy ;)
An experienced airhead electrician looking over it for a few hours might be able to trace current (forgive the pun) and future faults and I happen to be available....
 
Thanks for these wise words. I'll get on to them. I'm still keen to prolong this bike's life ( we go back a long way) so Tips on what needs looking at long term would be appreciated.
 
Neutral switch is an easy fix.
Can be done with the engine in situ. Remove the silencer, remove collector box (or Y piece)
Prop up rear of engine with a car jack. Remove rear engine mount through bolt. This will leave a hollow tube which can be levered down with a long screwdriver or tyre lever.
This gives access to the neutral switch. Undo the two wire, replace switch ( use a new crush washer)
Replace wires to neutral switch.
Meanwhile, stitch the cross tube in the freezer to cool and shrink it a little.
When cold, refit cross tube ( easier when it’s cold as it’s slightly smaller then)
Replace engine mount through bolt.
Replace collector box and silencer. Remove car jack from under engine ( not strictly necessary I believe, but I would always do it for peace of mind)

Sit back with a cold beer and congratulate yourself on a job well done
( until you discover that it was something else that caused the lack of starting!)

Ride safe y’all.
Brilliant response - right up to cold beer.... Thanks!
 
Neutral switch is an easy fix.
Can be done with the engine in situ. Remove the silencer, remove collector box (or Y piece)
Prop up rear of engine with a car jack. Remove rear engine mount through bolt. This will leave a hollow tube which can be levered down with a long screwdriver or tyre lever.
This gives access to the neutral switch. Undo the two wire, replace switch ( use a new crush washer)
Replace wires to neutral switch.
Meanwhile, stitch the cross tube in the freezer to cool and shrink it a little.
When cold, refit cross tube ( easier when it’s cold as it’s slightly smaller then)
Replace engine mount through bolt.
Replace collector box and silencer. Remove car jack from under engine ( not strictly necessary I believe, but I would always do it for peace of mind)

Sit back with a cold beer and congratulate yourself on a job well done
( until you discover that it was something else that caused the lack of starting!)

Ride safe y’all.

Don’t forget to drain the gearbox oil first 🤣

Oh, and I think you’ll find that is a 2 beer job 🍻
 


Back
Top Bottom